Reuse of Iraqi Agricultural Drainage Water Using Nanofiltration

Mohammad F. Abid; Saadi K. Al-Naseri; Samirra N. Abdullah

doi:10.6000/1929-6037.2013.02.01.6

Authors

Mohammad F. Abid Chemical Engineering Department-University of Technology, P.O. 35010, Baghdad, Iraq
Saadi K. Al-Naseri Ministry of Science and Technology, Baghdad, Iraq
Samirra N. Abdullah Chemical Engineering Department-University of Technology, P.O. 35010, Baghdad, Iraq

DOI:

https://doi.org/10.6000/1929-6037.2013.02.01.6

Keywords:

Agricultural water, Revers osmosis, Nanofiltration, Salinity, Antiscalant, Water reuse

Abstract

Irrigated areas between Euphrates and Tigris rivers in Iraq suffer from salinity buildup in the root zone of corps. Agricultural drain water (ADW) from these areas is collected in a single main drain canal, in an annual flow rate of about 6 billion cubic meter. In the present work, a pilot-scale nanofiltration membranes unit was used to evaluate the feasibility of desalinating ADW from the main drain canal for further reuse. Bench scale experiments were conducted to determine the optimum anti-scale dosage values in the unit. These values were verified in a plate type laboratory scale NF membrane to visually monitor the onset of crystal appearance behavior. A method for calcium sulfate precipitation control is presented and an empirical correlation of anti-scale dosage as a function of concentration factor (CF) was obtained. A pilot-scale unit was used to investigate the performance of NF membrane. High rejection values for both cations and anions indicate that the use of NF membrane in desalinating ADW from the Iraqi main drain canal is promising. The treated drainage water is considered good for irrigation when classified according to Wilcox classification.

References

Sorour MH, Abulnour AG, Talaat HA. Desalination of agricaltural drainage water. Desalination 1992; 86: 63-75. http://dx.doi.org/10.1016/0011-9164(92)80024-4 DOI: https://doi.org/10.1016/0011-9164(92)80024-4

Behnam S. Conference on Water management and pollution control in Iraq. Amman: s.n., 2001.

Le Gouellec YA, Elimelech M. Calcium sulfate (gypsum) scaling in nanofiltration of agricultural drainage water. J Membr Sci 2002; 205: 279. http://dx.doi.org/10.1016/S0376-7388(02)00128-X DOI: https://doi.org/10.1016/S0376-7388(02)00128-X

McCutchan WJ. Saline water research UCLA-ENG-7201. s.l.: Water resources desalination 1972; Report No. 47.

McCutchan WJ. Saline water progress report. s.l.: University of california 1975; 62: 25-34.

Ron WL, Julius G, Yoram C, Chris M, Kurt K. Low-pressure RO membrane desalination of agricultural drainage water. Desalination 2003; 155: 109-20. http://dx.doi.org/10.1016/S0011-9164(03)00288-1 DOI: https://doi.org/10.1016/S0011-9164(03)00288-1

Abid MF, Al-Nasri SK, Al-Salhi QA, et al. Desalination of Iraqi surface water using nanofiltration membrane. Desalination Water Treatment 2011; 29: 174-80. http://dx.doi.org/10.5004/dwt.2011.1845 DOI: https://doi.org/10.5004/dwt.2011.1845

Wilcox LV. The quality of water for irrigation use. US Department of Agriculture Technology Bulletin 1948; 49: 962.

APHA, AWWA, WEF. Standard Methods for the Examination of Water and Wastewater, 21st edition. Washington, D.C.: s.n., 1999.

Hanra AM, Ramachandhran V. RO performance analysis of cellulose acetate and TFC polyamide membrane systems for separation of trace contaminants. Desalination 1996; 104: 175. http://dx.doi.org/10.1016/0011-9164(96)00040-9 DOI: https://doi.org/10.1016/0011-9164(96)00040-9

Ismail AF, Lau WJ. Influence of feed conditions on the rejection of salt and dye in aqueous solution by different characteristics of hollow fiber nanofiltration membranes. Desalination and Water Treatment 2009; 6: 281-88. http://dx.doi.org/10.5004/dwt.2009.479 DOI: https://doi.org/10.5004/dwt.2009.479

Rautenbach R, Groschl A. Separation potential of nanofiltration membranes. Desalination 1990; 77: 73. DOI: https://doi.org/10.1016/0011-9164(90)85021-2

Marcus Y. Ion salvation. New York: Wiley 1985.